If you have a recliner lift that is ticking when trying to close, then it might be time to consult with your mechanic. The clicking sound can come from either the gears or springs.
This blog post will discuss the causes of a recliner lift motor ticking when closing and how your mechanic should diagnose this issue.
Causes of Ticking on a Recliner
#1. This is caused by worn-out gear that needs to be replaced.
#2. A broken spring can cause the motor to tick when closing if it’s not caught in time and fixed before damage occurs.
#3. If your seat has been reclined for long periods of time, then there might be dust or other debris on the gears which can cause the recliner lift motor to tick when closing.
#4. A loose wire might also be at fault if the recliner lift is ticking when trying to close, and this can sometimes happen due to animals chewing or climbing on it.
#5. The gears of a recliner that has been in use for many years could have worn out from age, and the motor can still work but it will not be as smooth.
#6. A recliner lift that has been left open for extended periods of time might also cause a ticking sound when closing. This happens because if the reclining mechanism stays in one spot it could wear down from age or heavy use over long periods of time.
#7. The motor of recliner lifts can also tick when closing if there is dirt and debris on the gears, which might need to be cleaned off with a little oil or WD40.
#8. A recliner lift that has been tampered with will likely have problems such as ticking sounds when trying to close it due to improperly installed parts that might need to be replaced.
#9. The recliner lift motor ticking when closing may also happen because of low power, which might mean the batteries are dying and need to be changed out before it can start working just as well as usual.
#10. A faulty recliner lift switch could make this noise if there is some form of dirt or debris on the gears that might need to be cleaned off with a little oil or WD40.
#11. If there is too much weight on one side of the recliner, it will not close properly and may tick when trying to move up into its upright position because this type of issue could require adjusting or replacing parts for it to function as expected.
#12. If the recliner is bumping against a hard object like an end table, it will tend to make this noise. Sometimes there might be other objects in the way that need moving or adjusting so it can close more smoothly and not have any problems with making ticking sounds when closing.
Steps on How to Fix Ticking on a Recliner
When reclining, the gears that are on the inside of the lift mechanism can sometimes make a ticking noise.
The following steps might help fix this problem:
Tip 1. Make sure there is no dirt or debris around these gears and try closing again. If it still sticks, you may need to remove some dust with oil or WD -40.
Tip 2. Check the cable to make sure it is not too tight or loose and try reclining again. If this still has a ticking noise, you may need to replace the gears inside with new ones (or at least remove them).
Tip 3. Make sure there are no objects in the way of your recliner that might be causing the ticking sound.
Tip 4. Check to make sure the reclining mechanism is in place and try again.
If, after following these steps, your recliner still ticks when closing it may be time for a new lift motor assembly (or just replacing the gears inside).
How to Avoid Ticking on Recliner Lift Motors:
#1. Check the recliner’s gears for dirt or debris and try reclining again.
#2. Make sure there is no small object in the way of your recliner that might be causing it to tick when closing.
#3. Adjust your cables to make sure they are not too tight or loose, then close again. If the ticking persists, you may need to replace your lift motor assembly.
#4. Clean the gear case of any debris – like hair or lint – and see if that helps with the ticking noise.
#5. If all else fails, consider a new recliner from Walmarts Furniture department!
How Much Does it Cost to Hire a Professional Recliner Repairer?
The average cost of recliner repair is around $150. However, this can vary based on the make and model of your chair. For example, a set of new gears for an electric lift motor will be more expensive than replacing the timing belt in a gas-powered one as well as when you need to hire someone to install them. If you have an expensive recliner chair, be prepared to spend more.
How Much Does a Recliner Lubricant Cost?
The cost of a recliner lubricant is around $25. This does not include installation or the purchase price for your reclining chair’s motor.
What are Some Other Ways to Prevent Noise?
Check the alignment of all pulleys and idlers before closing your chair – this can help reduce noise when running it as well as help the chair close more smoothly and quietly.
Clean your recliner’s motor to remove any dust or dirt that may be interfering with it – this can also reduce noise levels when running as well as make the operation smoother.